Volkswagen Golf V (2004 - 2008) - 06 1.4 abs esp arrr!

Honest John Back Room » Technical matters
View Threaded
Sat 27 Jun 2009 16:49
06 1.4 abs esp arrr! - vdub
14000 3years 3 months old miles needs new ABS pump £1500 from main dealer luckily covered by warranty direct as I extended the warranty thank goodness. local VW specialist doing the work. Already had the car for a full day, they said the pump was fitted in two hours but they have trouble configuring the pump. ABS and esp lights still on in road test mode. apparentley they have to do road test with the car plugged into a laptop to configure pump put car will not accept pump yet. ABS and traction working now but lights still on. I will have to take car in again. This is a regular problem with VW cars I am told . I read on a forum that turning the ignition on and off many times should clear the fault and ecu will eventually recognise the new ABS pump.
Reply | Report as offensive | Link
Sat 27 Jun 2009 17:26
06 1.4 abs esp arrr! - injection doc
all they need to do is to retrive the code out of the old pump & configure the new module using the access code. Its not rocket science & never had a problem unless they have mis diagnosed the faults & its an SAS fault
Reply | Report as offensive | Link
Sun 28 Jun 2009 12:21
06 1.4 abs esp arrr! - vdub
the car has to be driven on the road to configure the ecu or pump whatever .drive at 15km/hr then turn steeering 90deg left then right to config the lateral sensors, a figure of eight type seris of turns should do it so I am told. The abs pump fault was verified by independent vw specialist and main dealer diagnostics as asked for by warranty direct.
Reply | Report as offensive | Link

10 warranty myths exposed

Here’s how to sort the fact from the fiction when it comes to car warranties.

Cheap Car Warranties

Looking for a garage you can trust? Honest John's Good Garage Guide has thousands of reader recommended garages, plus how-to guides and tips on servicing.

The Good Garage Guide