Peugeot 306 (1993 - 2001) - 95 1.9dt engine transplant

Honest John Back Room » Technical matters
View Threaded
Thu 31 Dec 2009 00:45
95 1.9dt engine transplant - vonnie
hi there

ui have recently bought a 306 with a nakerd engine

i have went and bought a replacement engine and fittef it no problem

i now hav the car sitting causing me a headache

it does not turn over from the key to start, i have a remote key with the central locking buttons on it that do not work, (possibly a battery in key?.)

i am not shure if the pumps are coded or imoiliser makes a dif ?

any help would be much apreciated thanks

Edited by Dynamic Dave on 31/12/2009 at 01:33

Reply | Report as offensive | Link
Thu 31 Dec 2009 11:45
95 1.9dt engine transplant - sarka1230
HI is there a small button on the steering coloum near the ignition key if so lock and unlock the car with the key then press the button on steering coloum should then start this isnt the hdi motor is it ? if it is the pump could be coded but motor should turn over hope this helps you also need to press this button if you disconect the battery at any time steve
Reply | Report as offensive | Link
Thu 31 Dec 2009 15:16
95 1.9dt engine transplant - Peter.N.
Does it have a keypad? If not you have no code problem providing the car the engine came out of didn't have a keypad, but you would probably know that because it would have a multi connector to the pump instead of one wire. If the starter is not turning sounds more like an electrical fault or a duff starter.

Try connecting a wire from the + terminal of the battery to the small terminal on the starter, if it turns you have a fault in the ignition circuit, if not the starter is faulty.
Reply | Report as offensive | Link
Fri 1 Jan 2010 13:21
95 1.9dt engine transplant - vonnie
thanks for the replys. il hav to double check with the button as all the plastics were off the colum when i pikd the car up, the starter is fine as i have already bridged the wires to get it to turn over ?
there is no keypad either
Reply | Report as offensive | Link
Fri 1 Jan 2010 14:11
95 1.9dt engine transplant - Peter.N.
If neither car has a keypad you are rid of the worst nightmare, it can only be a faulty ignition switch or a glitch in the wiring I would think.
Reply | Report as offensive | Link
Fri 1 Jan 2010 21:35
95 1.9dt engine transplant - sarka1230
no key pad almost certain its just the reset button near ignition key but you must lock and unlock doors before pressing button cant rember if ignition should be on or off when pressing try both
Reply | Report as offensive | Link
Sat 2 Jan 2010 01:35
95 1.9dt engine transplant - vonnie
thanks again lads

i have the key with the central locking buttons on it but that does not work, poss a flat battery ion key ? will this matter ?
Reply | Report as offensive | Link
Tue 5 Jan 2010 00:33
95 1.9dt engine transplant - sarka1230
remote locking not working shouldn't be a problem ,what happens to the dashboard warning lights when you turn the key to start it? ie do they all dim ,stay the same or just one dim? could be a duff or jammed starter motor steve
Reply | Report as offensive | Link

If you cover no more than 100 miles per day and have easy access to a charging point at home or work, then an EV is ideal for you.

Is an electric car right for me?