FIAT DUCATO 2.0 JTD 2004 - FIAT DUCATO 2004 ENGINE CUTTING OUT

Honest John Back Room » Technical matters
View Threaded
Sun 14 Feb 2016 19:59
FIAT DUCATO 2.0 JTD 2004 - FIAT DUCATO 2004 ENGINE CUTTING OUT - CHASETRAILBUILDA

I have a Fiat Ducato 2.0 JTD,

At 2350 rpm the engine will either cut out or go into Limp mode. If i then turn off the ignition for a few seconds and restart it, it runs again. I can drive it all day long, justg as long as I don't go over 2350rpm.

This only occurs when the engine is warm (ie the temp needle starts to move), before that it'll rev fine.

It also, only happens under load. If I'm stationary, it doesn't matter if the engine is hot or cold, it will rev to it's limit.

I have changed the EGR valve and just about every sensor, I have also put a computer on it which gives an error code saying ''Invalid signal from the Fuel pressure censor''.

Any ideas? It's driving me nuts.

Reply | Report as offensive | Link
Sun 14 Feb 2016 22:32
FIAT DUCATO 2.0 JTD 2004 - FIAT DUCATO 2004 ENGINE CUTTING OUT - elekie&a/c doctor
What is the fuel pressure when you reach the critical cut out speed?
Reply | Report as offensive | Link
Wed 15 Mar 2017 23:34
FIAT DUCATO 2.0 JTD 2004 - FIAT DUCATO 2004 ENGINE CUTTING OUT - Bosa Boss

Hi mate, did you manage to find out the problem with your van, I have exactly the same problem and have run out of ideas.

Thanks

Reply | Report as offensive | Link

Looking for a garage you can trust? Honest John's Good Garage Guide has thousands of reader recommended garages, plus how-to guides and tips on servicing.

The Good Garage Guide