toyota estima - cold starting issue

Honest John Back Room » Technical matters
View Threaded
Thu 21 Jan 2016 20:21
toyota estima - cold starting issue - petem8

I have an issue with cold starting on my estima 3ct diesel 93.

This being since the temperature outside dropped before that the vehicle started and ran ok. I now have to sit and press the accelerator pedal,turn the key and start the engine hold the fast tickover till it warms up a little then all is fine. I have naver had to sit in the vehicle with this procedure before so something amiss. I have looked at the pump as I turn the key and noticed there is no movement on the fast idle control. Anyone any ideas please. Regards.

Reply | Report as offensive | Link
Thu 21 Jan 2016 20:40
toyota estima - cold starting issue - RobJP

Next cold morning, get in the car, turn the key until the ignition is on ( NOT until the engine cranks), and wait 10 seconds. Then try starting it normally.

It could be the glow plugs starting to fail, it could be a fuel pump starting to fail, it could even be a fuel filter getting clogged up or partially filled with water.

Reply | Report as offensive | Link
Thu 21 Jan 2016 23:44
toyota estima - cold starting issue - Wackyracer

You'd be better asking the question on the TEOC website, their chairman is a specialist in Estima's.

Reply | Report as offensive | Link
Fri 22 Jan 2016 19:30
toyota estima - cold starting issue - petem8

Many thanks all. All obvious faults eliminated. With the throttle held open the car will start no prob but will not tickover smoothly untill engine gets a little warm.then fine. I am trying to get membership confirmation from TEOC but no response and an email to the club estima guru has also failed. Ill keep on trying to sort it.

Many thanks again all. Regards.

Reply | Report as offensive | Link
Fri 22 Jan 2016 23:28
toyota estima - cold starting issue - Wackyracer
Try giving Bob Murphy a call, he is very helpful and knows his stuff when it comes to Estima's.
Reply | Report as offensive | Link
Mon 25 Jan 2016 19:20
toyota estima - cold starting issue - petem8

Hi wackyracer,

Thanks for that info. but I need contact info can you help with that. Regards.

Reply | Report as offensive | Link
Mon 25 Jan 2016 23:01
toyota estima - cold starting issue - Wackyracer

You can call Bob Murphy on 07931 547438 or email him on rcmvr@aol.com

rcmvr.co.uk/

Edited by Wackyracer on 25/01/2016 at 23:02

Reply | Report as offensive | Link
Tue 26 Jan 2016 19:30
toyota estima - cold starting issue - petem8

Cheers for that mate much appreciated. Ill see how it goes with this contact.

Regards.

Reply | Report as offensive | Link
Fri 26 Feb 2016 19:53
toyota estima - cold starting issue - petem8

Managed to find a guy name of Gary at G T Motors who gave me info on the cold start idle control timer which is a device connected to the idle control fixed at the back of the fuel pump and has two coolant pipes connected to it. When cold the devie contracts which pushes the idle lever to a fast idle as the temperature increases the device expands reducing the idle speed. My issue was caused by a blockage in one of the coolant pipes which made the device inoperative. Sorted. Many thanks to all who helped.

Reply | Report as offensive | Link
Fri 10 Jun 2016 11:46
toyota estima - cold starting issue - otomotor

Glad to hear that you got it sorted! I had been reading your commets and wondered. They are reliable cars so glad you managed to work out the issue and are back up and running.

Reply | Report as offensive | Link

Looking for a garage you can trust? Honest John's Good Garage Guide has thousands of reader recommended garages, plus how-to guides and tips on servicing.

The Good Garage Guide