vauxhal vectra 1.9 cdti 150 - reving issue

Honest John Back Room » Technical matters
View Threaded
Sat 15 Sep 2012 20:38
vauxhal vectra 1.9 cdti 150 - reving issue - pad73
hi can anyone help ive got a vectra 1.9 cdti 150 on a 54 plate when im in second gear an i get to 2.5 revs it holds back an then it seems to clear an carrys on though the rev range not to clued up on diesal what could it be?? i thought it might be glow plugs any help would be greatful
Reply | Report as offensive | Link
Sun 16 Sep 2012 12:03
vauxhal vectra 1.9 cdti 150 - reving issue - Simoncelli58

Sounds like your swirl flaps have fell off.

Take the plastic engine cover off (it pops off) and have a look.

If it's fell off you'll need a new intake manifold,or you can glue it back on.

Do a search on the Vauxhal forums.

Very common on a Vectra that age.

Reply | Report as offensive | Link
Sun 16 Sep 2012 18:55
vauxhal vectra 1.9 cdti 150 - reving issue - pad73
thanks were abouts should i be looking for it?
someone mention it might be turbo lag cause it doesnt do it all the time
Reply | Report as offensive | Link
Sun 16 Sep 2012 20:15
vauxhal vectra 1.9 cdti 150 - reving issue - Simoncelli58

If you don't know where to find your inlet manifold,you may do more harm than good (sorry) !

Try looking on the vectra C forum

Vectra-C.com

Loads of help and good information there.

And a 'How to' section

But if your not too good with cars,take it to your local INDEPENDENT garage.

Don't go to a Dealer,they are hopeless and a money pit.

Most problems with these are down to vacuum faults or swirl flaps.

A code read really is the place to start !

Good Luck

Edited by mickyh7 on 16/09/2012 at 20:17

Reply | Report as offensive | Link
Sat 22 Sep 2012 21:52
vauxhal vectra 1.9 cdti 150 - reving issue - pad73
thanks
Reply | Report as offensive | Link
Mon 17 Sep 2012 15:41
vauxhal vectra 1.9 cdti 150 - reving issue - uksant

Had a similar problem with an Audi A4 1.9 tdi a few months ago - in 1st & 2nd gear was ok up to 2 - 2.2k revs and then no power (i.e. 'held back') and then suddenly a surge of power after 2.3k revs with lots of smoke out the back. Took it to an independent VW specialist. Split turbo boost pipe. £80 to fix all-in.

So, basically, would advise you take it to an independent GM / Vauxhall specialist.

Reply | Report as offensive | Link
Sat 22 Sep 2012 21:54
vauxhal vectra 1.9 cdti 150 - reving issue - pad73
thanks
Reply | Report as offensive | Link
Tue 16 Oct 2012 00:33
vauxhal vectra 1.9 cdti 150 - reving issue - pad73
hi guys just a up date had a code that come up was p1125 throttle sensor took off the throttle body look under the sensor the an the cogs on it had sheared off another common fault on this engine £200 to repair all my power is back happys days fingers cross no more problems
Reply | Report as offensive | Link