Vauxhall corsa C 1.0l - Horrible rattle on startup

Honest John Back Room » Technical matters
View Threaded
Thu 16 May 2013 21:08
Vauxhall corsa C 1.0l - Horrible rattle on startup - Tommk4

I get a terrible rattleing noise for the 1st second or two upon startup. Mostly when cold, it isnt too bad when it's been warmed up.

The car is high miliage (nearly 130k) and its the 3 cyl 1.0L engine and it gets very regualr oil changes. No smoke.

Does anyone have any experience of this? Could it just be hydraulic tappets running for a second without oil or is it something more serious?

Reply | Report as offensive | Link
Thu 16 May 2013 21:25
Vauxhall corsa C 1.0l - Horrible rattle on startup - Cyd

Tomorrow morning get the bonnet up and listen intently as someone starts it up for you. Then come back and try and describe the noise and what area of the engine it's coming from (in particular, the top end or bottom end).

It could be tappets or a variety of other things. You are using the correct oil type and grade?

Reply | Report as offensive | Link
Thu 16 May 2013 21:42
Vauxhall corsa C 1.0l - Horrible rattle on startup - Tommk4

I've had a good listen and it definatley seems to be a top end noise, obviously its difficult to describe the noise but I once had a ford CVH with a dodgy worn out tappet and it sounds a bit like that but a more frequent ie faster noise.

Any ideas how much a new chain would be?

Would it be of any use if I video'd it on my phone and put it on youtube?

Reply | Report as offensive | Link
Thu 16 May 2013 21:26
Vauxhall corsa C 1.0l - Horrible rattle on startup - elekie&a/c doctor

I would say more serious.Very likely to be the timing chain on its last legs.Needs to be looked at sooner rather than later.hth

Reply | Report as offensive | Link
Thu 16 May 2013 21:47
Vauxhall corsa C 1.0l - Horrible rattle on startup - Cyd

yeah, like the youtube idea.

Reply | Report as offensive | Link
Thu 16 May 2013 22:10
Vauxhall corsa C 1.0l - Horrible rattle on startup - Tommk4

OK, video uploading. Now.

Reply | Report as offensive | Link
Thu 16 May 2013 22:35
Vauxhall corsa C 1.0l - Horrible rattle on startup - Tommk4

http://youtu.be/_PiP8HxSUzE

That link should take you to it. Note my comedy run too and from the car to turn the camera on/off!

It sounds a bit tappety the whole time but I think they all do, you can definatley tell the noise I'm on about when I start it nthe first time.

Reply | Report as offensive | Link
Sun 26 May 2013 21:33
Vauxhall corsa C 1.0l - Horrible rattle on startup - brumex1

sounds like a normal 1.0 to me just a bit of oil drained away from parts mines the same

Reply | Report as offensive | Link
Thu 30 May 2013 05:03
Vauxhall corsa C 1.0l - Horrible rattle on startup - 1litregolfeater

Drain the crap oil and replace with 3.5 litres of 5W30 synthetic.

Reply | Report as offensive | Link