Ford 1.8D Start Problem (Again!!!!)

Honest John Back Room » Technical matters
View Threaded
Sat 22 Mar 2003 18:09
Ford 1.8D Start Problem (Again!!!!) - razamataz
Hi to group - My wifes fiesta 1.8D has had poor starting since the first frost. The car eventually starts after a lot of cranking then runs fine all day long, until the next frost - so I replaced the glow plugs. No improvement. I changed the fuel filter. No improvement - in fact the problem has recently got worse and the car now fails to start completely. I have tried bleeding air from filter unit bleedscrew but when turning the engine over there is no fuel coming out (although I can get fuel at the injector unions!). The hand primer button freely moves in and out but despite continued pumping by hand or by key no pressure is built up. I have searched previous posts and the filter housing/seals seem to a prob with this engine but I have no fuel leaks. Can anybody please offer advice - the car is in autotrader as my wife can\'t trust it anymore and has bought a replacement!. Thanks in advance.
Reply | Report as offensive | Link
Sat 22 Mar 2003 18:16
Ford 1.8D Start Problem (Again!!!!) - Big Gaz
sounds like the seal has gone in the primer, it will move but will not build pressure. Had same thing on Mondeo when changed fuel filter. had to get new primer unit from local car spares shop.
Reply | Report as offensive | Link
Sat 22 Mar 2003 18:21
Ford 1.8D Start Problem (Again!!!!) - razamataz
Hi thanks v much for response and so quick!.
Kind Regards
Tony
Reply | Report as offensive | Link
Sat 22 Mar 2003 18:25
Ford 1.8D Start Problem (Again!!!!) - Big Gaz
No Probs mate, i think its a common Ford Problem, the primer used to be a Ford only part, but its now available as a pattern part. Hope this solves the prob. Gaz
Reply | Report as offensive | Link
Sun 23 Mar 2003 17:27
Ford 1.8D Start Problem (Again!!!!) - Railroad
Also change the manufactured fuel pipe between the fuel filter and injection pump. A common area for drawing air.
Reply | Report as offensive | Link
Mon 24 Mar 2003 18:55
Ford 1.8D Start Problem (Again!!!!) - razamataz
Thanks again for advice - as an update have just fitted a new primer/filter housing unit (£30 VAT Hitech at Bury, Lancs - Ford wanted £50.01 VAT). Took fifteen minutes to change and jump start it and, after a spot of air bleeding, is running like a dream. Good job really - it\'s in Autotrader for sale!. Will change fuel pipe as recommended to be on safe side. Thanks V Much again to both of you. Tony
Reply | Report as offensive | Link

We give you the low down on how to save on insurance, little-known tricks and tips, what insurance groups mean and how to use insurance aggregators to beat insurers.

Insurance group finder and how to save on insurance

Looking for a garage you can trust? Honest John's Good Garage Guide has thousands of reader recommended garages, plus how-to guides and tips on servicing.

The Good Garage Guide