Volkswagen Golf tsi - Won't go over 3000rpm limp mode ?

Honest John Back Room » Technical matters
View Threaded
Fri 15 Mar 2013 14:57
Volkswagen Golf tsi - Won't go over 3000rpm limp mode ? - adamdav
Hi last night had major issue with my golf heading up slip road put foot down got to 3000rpm would not go any more than 3000rpm in any gear could not hear the supercharger like a usually could I ended up with a fault code p10a4 n went digging thro google etc also noticed that they recommend you use a high octane fuel higher than 95 Ron not sure if this is what caused problem by time got home the engine management light had came on but next day it had gone car was back to normal anyone else had issues like this I phone vw with fault code they never knew what it was on hours of searching google someone said about supercharger flap failing ??? Any info would be great
Reply | Report as offensive | Link
Fri 15 Mar 2013 15:24
Volkswagen Golf tsi - Won't go over 3000rpm limp mode ? - Collos25

I believe they have quite a complicated EGR system built into the inlet manifold which can cause grieve but by your description the turbo is not working this could be caused by many reasons,be careful that the oil seals have not gone and the engine is not sucking in engine oil.It should run perfectly normal on Euro 95.

Reply | Report as offensive | Link
Fri 15 Mar 2013 20:02
Volkswagen Golf tsi - Won't go over 3000rpm limp mode ? - Bromptonaut

Not a Golf, not petrol and not a supercharger but my Citroen Xantia ocasionally puts on it's engine management light and/or goes limp mode. Can be just a transient fault or a flap/valve that's slow to open or close.

If it's cleared I'd suggest it's not too serious but get a specialist to look at it. MAybe just stuff that needs a clean.

Reply | Report as offensive | Link
Sat 16 Mar 2013 00:38
Volkswagen Golf tsi - Won't go over 3000rpm limp mode ? - adamdav
Yeah egr system not simple youtu.be/20qqavckWdw found this on you tube to try understand it not had any problems today have put shell v power in it not sure if its just in my head but seems more responsive in throttle response but been on few forums to see if anyone else had same thing seen a few some suggested knock sensor then in handbook and on petrol flap recommends super unleaded fuel so shall see how that goes but think should of kept my fabia vrs never had any issues this golf also had spark plugs changed twice as well as coils :-(
Reply | Report as offensive | Link
Fri 15 Mar 2013 23:41
Volkswagen Golf tsi - Won't go over 3000rpm limp mode ? - Avant

Moved to Technical.

Reply | Report as offensive | Link
Sat 16 Mar 2013 07:38
Volkswagen Golf tsi - Won't go over 3000rpm limp mode ? - injection doc
The clutch for the supercharger is temperamental as our the change over flaps in the induction system and turbo waste gates are prone to sticking ! The clutch for the supercharger is a whole water pump assembled and a pig to fit ! Done a few ! To be honest these engines are very temperamental and once they reach 50k plus they a can be a wallet bender! Coil packs, plugs and pistons are all poor.
Best to have a proper diagnostic check and look in faults pending in EOBD, and freeze frame. Conditions are captured as they happen and most techs forget to check there first.
Reply | Report as offensive | Link
Sat 16 Mar 2013 11:51
Volkswagen Golf tsi - Won't go over 3000rpm limp mode ? - adamdav
Ah fab mine nearly at 60000 miles I knew should of kept the fabia vrs diesel never had any issues anyone know of any upgrades that would help it i seen also on few forums in ref to coils about an ecu upgrade that vw were doing just not had time to go out to vw but car seems to be fine now mate had diagnostic plugged it that's where got the code and after hours on google found another one they seem to have more problems when its dsg as well
Reply | Report as offensive | Link
Wed 11 Sep 2013 19:17
Volkswagen Golf tsi - Won't go over 3000rpm limp mode ? - tsi dan 354
Same probs same code what was the out come if you don't mind me asking need some help
Thanks
Reply | Report as offensive | Link

Looking for a garage you can trust? Honest John's Good Garage Guide has thousands of reader recommended garages, plus how-to guides and tips on servicing.

The Good Garage Guide