Peugeot 306 (1993 - 2001) - 1998 1.9td How to replace fan belt ? | Technical matters | Back Room Forum

Wed 10 Dec 2008 20:15

1998 1.9td How to replace fan belt ? - wolfmeister

Hi, just wondered if anyone can help.
THe main crank pulley has come of my 1.9 td - the one which is also drives the cam belt.
In order to refit the pulley I need to refit the fan/auxilary belt. However the Haynes manual as ever has no mention of this or any diagrams. A friend of mine has done this for me in the past and did say what a jolly awkward blighter it was to do!
Can anyone give me any pointers or explain the route round the pulleys.

Any help greatly appreciated.

Edited by Dynamic Dave on 10/12/2008 at 21:24

Reply | Report as offensive | Link

Wed 10 Dec 2008 20:40

1998 1.9td How to replace fan belt 306 1.9 td - hm

Mate, I do not want to insult you... Pug 306 does not a fan belt.. she has electric fans.

But I do know the belt you are talking about.... and I also know the Mr Haynes gives a good description on how to replace / change belt (with a diagram of the belt layout) I sold my trusty DT a good few years ago, but I know that detail were there.

when looking at the belt from the driverside wheel arch near the front of the block there's a roller sit's on the belt, in the middle of the roller is 1 allen key bolt (6mm if my mind serves me correctly)........... lower down is another allen key bolt........... and then upside down on the bottom is another allen key bolt.... this is the adjuster for the tension.....loosen the top two, then the bottom one winds out to tighten the belt.... in the haynes manual is a diagram showing the correct routing for the belt.. I know it is there somewhere....

Laters

H

Reply | Report as offensive | Link

Related questions

Cam belt replacement - age or mileage?

My Volkswagen Tiguan, owned from new, is almost five years old but has only covered 26,500 miles. Volkswagen say the cam belt should be replaced at five years or 100,000 miles but cannot tell me why the...

When should I change the cam belt on my car?

My SEAT Ateca has done 70,000 miles and is four and a half years old, when should the cam belt be changed?

When should you change the timing belt on a car?

When would you recommend replacing the timing belt on a car?

When should I replace the cam belt on my Skoda Yeti?

My Skoda Yeti had a cam belt and water pump changed five years ago at 48,000 miles. I haven't used the car much over the past two years, but at 78,000 miles (and five years later) my local garage is advising...

Ask Honest John

Sell Your Car

Real MPG

Fuel Calculator