Ford Focus (1998 - 2004) - 2001 1.6 Repeated Blown Fan Resistor Packs

Honest John Back Room » Technical matters
View Threaded
Wed 3 Dec 2008 20:05
2001 1.6 Repeated Blown Fan Resistor Packs - backtodiesel
I have replaced the resistor pack in my ford focus for the second time in a few months and just in case replaced the pollen filter at the same time. This time it only lasted a couple of days before blowing again. I noticed that after replacing the resistor pack that the blower made a squeaking noise (dodgy bearings) afterwards.

Should I replace the resistor pack again or is my problem much bigger?... I thought I might need the blower replaced?

Any suggestions/help welcome.
Reply | Report as offensive | Link
Wed 3 Dec 2008 20:15
2001 1.6 Repeated Blown Fan Resistor Packs - elekie&a/c doctor
a blown resistor pack is normally caused by the fan motor drawing too much current.Usually a worn motor.In fact it is often the thermal circuit breaker that fails on top of the resistor unit (small tube like device)rather than the resistive element.Also make sure the 4-pin connector is not burnt or overheated.hth
Reply | Report as offensive | Link

Looking for a garage you can trust? Honest John's Good Garage Guide has thousands of reader recommended garages, plus how-to guides and tips on servicing.

The Good Garage Guide